Regency Sunrise U32S-NG5 Manuel d'utilisateur

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4918-788MODELS: U32S-NG5 Natural Gas U32S-LP

10 U32S-5 FPI Direct Vent Gas InsertGAS PIPE PRESSURE TESTINGThe appliance must be isolated from the gas supply piping system by closing its individua

11U32S-5 FPI Direct Vent Gas InsertCONVERSION KIT # 434-969 FROM NG TO LP U32S-5 using SIT 820 NOVA Gas ValveINSTALLATION THIS CONVERSION MUST BE DON

12 U32S-5 FPI Direct Vent Gas InsertINSTALLATIONWARNING!Do not overtighten the screw. Recommended to gripthe wrench by the short side.13) Turn contro

13U32S-5 FPI Direct Vent Gas InsertINSTALLATION 4) Connect the DC spark generator wires to the SIT Valve with the screw, which is provided in the kit

14 U32S-5 FPI Direct Vent Gas InsertThe remote control kit comes with a hand held transmitter, a receiver and a wall mounting plate.1) Choose a conve

15U32S-5 FPI Direct Vent Gas InsertPiezoIgnitorBlackRedToThermocouple INPilotAssemblyThermostat(Optional)(Millivolt)RemoteReceiver(Optional)(Millivolt

16 U32S-5 FPI Direct Vent Gas InsertFor PROPANE Units and Units Equipped with DC Spark Boxes**For installation of the DC Spark Box refer to the LP Con

17U32S-5 FPI Direct Vent Gas InsertINSTALLATION GLASS CRYSTAL OR OPTIONAL CERAMIC STONESINSTALLATION ON BURNER Burner shown with Glass CrystalsBurner

18 U32S-5 FPI Direct Vent Gas InsertINSTALLATIONDiagram 3Diagram 2To remove the fl ush door, reverse the above steps.IMPORTANT NOTE: The chain must res

19U32S-5 FPI Direct Vent Gas InsertINSTALLATION FACEPLATE AND DOOR FRAME INSTALLATION3) Position faceplate on unit lining up screw holes on faceplate

2 U32S-5 FPI Direct Vent Gas InsertTO THE NEW OWNERCongratulations! You are the owner of a state-of-the-art Gas Insert by FPI.The U32 Sunrise Gas Ins

20 U32S-5 FPI Direct Vent Gas Insert7) Install the door frame by hooking the top fl ange over the top of the glass door.9) Run supplied 120V power co

21U32S-5 FPI Direct Vent Gas InsertINSTALLATION The Hearth Trim is an option that can be used to fi nish off the installation when the bottom of the fi

22 U32S-5 FPI Direct Vent Gas InsertThe glass panel may require cleaning after the unit has cooled down. DO NOT ATTEMPT TO CLEAN THE GLASS WHILE IT I

23U32S-5 FPI Direct Vent Gas InsertCOPY OF LIGHTING INSTRUCTION PLATEOPERATING INSTRUCTIONSslightly different rates which can cause "ticking"

24 U32S-5 FPI Direct Vent Gas InsertMAINTENANCEGENERAL VENT MAINTENANCEConduct an inspection of the venting system semi-annually. Recommended areas to

25U32S-5 FPI Direct Vent Gas InsertFAN MAINTENANCEIf your fan requires maintenance or replacement, access to the fan is through the plate on the rear

26 U32S-5 FPI Direct Vent Gas Insert9) Remove the base cover by lifting up from the back and maneover out.Base Cover14) Remove the fan access plate b

27U32S-5 FPI Direct Vent Gas InsertMAINTENANCE21) Disconnect green ground wire from power cord.REPLACING THE FAN Scrape off the old gasket from th

28 U32S-5 FPI Direct Vent Gas Insert1) Turn the unit off and allow it to cool down to room temperature.2) Disconnect the power source and turn off t

29U32S-5 FPI Direct Vent Gas InsertMAINTENANCE10) Remove the valve tray by undoing the 12 screws as shown below.11) Slightly lift out valve tray.12) D

3U32S-5 FPI Direct Vent Gas InsertTABLE OF CONTENTSOPERATING INSTRUCTIONSOperating Instructions ...22Lig

30 U32S-5 FPI Direct Vent Gas InsertPARTS LIST1) 420-122 Fan Access Panel2) 420-142 Gasket - Fan Access Panel 422-518/P Fan Assembly:3) 910-215/P

31U32S-5 FPI Direct Vent Gas InsertPARTS LIST1) 910-568 Valve - SIT NG / LP2) 904-430 Burner Orifi ce Nat. Gas #42 904-163

32 U32S-5 FPI Direct Vent Gas InsertPARTS LISTFACEPLATE AND DOORFRAME3121) 425-512 Door Bottom Assembly2) 425-513 Frame Inside3) 425-514 Face

33U32S-5 FPI Direct Vent Gas InsertNOTES

34 U32S-5 FPI Direct Vent Gas InsertNOTES

35U32S-5 FPI Direct Vent Gas InsertWARRANTYRegency® Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal

36 U32S-5 FPI Direct Vent Gas InsertInstaller: Please complete the following informationDealer Name & Address: ___________________________________

4 U32S-5 FPI Direct Vent Gas InsertSAFETY LABELThis is a copy of the label that accompanies each U32S-5 Gas Insert. We have printed a copy of the cont

5U32S-5 FPI Direct Vent Gas InsertREQUIREMENTS 5.08: Modifications to NFPA-54, Chapter 10(2) Revise 10.8.3 by adding the following additional requirem

6 U32S-5 FPI Direct Vent Gas InsertUNIT DIMENSIONS

7U32S-5 FPI Direct Vent Gas InsertIMPORTANT MESSAGE SAVE THESE INSTRUCTIONSThe FPI Gas Insert must be installed in accordance with these instruction

8 U32S-5 FPI Direct Vent Gas InsertGKLABCABDEC MANUFACTURED MOBILE HOME ADDITIONAL REQUIREMENTS1) Ensure that structural members are not cut or weake

9U32S-5 FPI Direct Vent Gas InsertVENTINGTHE APPLIANCE MUST NOT BE CONNECTED TO ACHIMNEY FLUE SERVING A SEPARATE SOLID FUELBURNING APPLIANCE.This appl